Effects of metal ions and wood pitch on retention and physical properties of TMP

Xiaomin Lu*, Anna Sundberg, Anders Strand, Martin A. Hubbe

*Tämän työn vastaava kirjoittaja

Tutkimustuotos: LehtiartikkeliArtikkeliTieteellinenvertaisarvioitu

1 Sitaatiot (Scopus)
19 Lataukset (Pure)


The influence of metal ions, Ca2+and Mg2+, on wood pitch retention at pH 8 was studied by investigating the pitch content of TMP-papers using both short- and long-column gas chromatography (GC). The effects of two different drying methods, air-drying and freeze-drying, on pitch retention were also compared in this work. The pitch emulsion was prepared with fatty acids, resin acids, and triglycerides at a certain ratio to simulate the pitch composition in closed water system in paper mill. At increasing pH, some of the resin and fatty acids will dissolve into the water phase as metal soaps. In this work, the retention of colloidal pitch in TMP-papers by metal ions at pH 8 was determined. The amount of 5 mM metal ions was found to retain more pitch. The tensile index decreased by the addition of metal ions, and the decrease became more pronounced as the increase of the metal ions concentration. Besides, the hydrophobicity of handsheets was found being changed only a little, which might because the morphology and pitch retained on the surface both affected the hydrophobicity.

JulkaisuNordic Pulp and Paper Research Journal
DOI - pysyväislinkit
TilaJulkaistu - 24 syysk. 2020
OKM-julkaisutyyppiA1 Julkaistu artikkeli, soviteltu


Sukella tutkimusaiheisiin 'Effects of metal ions and wood pitch on retention and physical properties of TMP'. Ne muodostavat yhdessä ainutlaatuisen sormenjäljen.